AdBlue Repair Expert — mobile AdBlue, SCR and NOx specialistsAdBlue Repair Expert

AdBlue system malfunction

"AdBlue System Malfunction" — What It Means and How We Fix It

24/7 mobile AdBlue, SCR & NOx assistance — we come to you

This message means the vehicle has detected that AdBlue dosing or NOx reduction isn't working properly. Most vehicles then start a countdown to a no-start. Don't wait for it to hit zero — call or WhatsApp us with the reg and a photo of the dash.

Call 24/7WhatsApp 24/7

Mobile call-out from £150 minimum. Final cost depends on the vehicle, location, diagnosis and work required. Contact us now for current technician availability and ETA.

Most repairs are completed on site in 1–3 hours, depending on the fault and the vehicle. Already immobilised by the AdBlue system? We can get vehicles started again once the underlying fault is diagnosed and repaired.

Common causes

  • NOx sensor failure (upstream or downstream)
  • AdBlue pump not building pressure
  • Blocked or crystallised dosing injector
  • Tank heater or level/quality sensor fault
  • Wiring, connector or software/calibration faults

How long can I keep driving?

Check the dashboard: many vehicles show miles or starts remaining. Once it reaches zero, the engine won't restart after it's switched off. If you're close, keep the engine running only if safe and contact us.

What we check and how the job works

We read every relevant module, test live dosing, pressure and sensor data, then show you what's failed before any part is fitted. Most repairs are completed on site in 1–3 hours, depending on the fault and the vehicle.

Keep reading

Mobile service area

AdBlue system malfunction — fixed at your location

We are based in Staines-upon-Thames (TW18) and cover every town below, 24 hours a day. Pick your area to see local cover, or send us the registration and the exact dashboard wording and we will tell you what we are looking at.

Answers

Common questions

+Will topping up AdBlue clear the malfunction message?

Only if the cause was low or poor-quality AdBlue. A 'malfunction' message usually means a component or sensor fault.

+Can you come out if the vehicle won't start?

Yes. Already immobilised by the AdBlue system? We can get vehicles started again once the underlying fault is diagnosed and repaired.

24 hours a day, 7 days a week

24/7 emergency AdBlue help

Send us the registration and the exact dashboard wording. Mobile call-out from £150 minimum. Final cost depends on the vehicle, location, diagnosis and work required. Contact us now for current technician availability and ETA.

Call 24/7 — 07347 492822WhatsApp 24/7
Call 24/7WhatsAppGet help